Product ID:MARINE SPAR VARNISH GLOSS, 724-7557
MSDS Date:08/23/1995
FSC:8010
NIIN:00N087619
MSDS Number: CHTCX

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: MART2

Telephone: 216-566-2902

Cage: MART2

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL

CAS: 64742-88-7

Fraction By Weight: 49%

OSHA PEL 100 PPM (MFR)

ACGIH TLV: 100 PPM (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN & RESP SYS.
MAY CAUSE NERV SYS DEPRESS. EXTREME OVEREXP MAY RSLT IN UNCON &
POSS DEATH. SIGNS & SYMPS OF OVEREXP: REDNESS & ITCH/BURNING
SENSATION MAY INDICATE EYE/EXCESS SK IN EXPOS. HDCH, DIZZ, NAUS, &
LOSS OF CONSCIOUSNESS ARE INDICATIONS OF EXCESS EXPOS TO VAPS/SPRAY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: MISTS. CHRONIC: PRLNG OVEREXP TO
SOLVS MAY CAUSE ADVERSE EFTS TO LIVER & URINARY SYS. RPTS HAVE
ASSOC RPTD & PRLNG OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. EYES:
FLUSH WI TH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION. INGESTION: GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:102F,39C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZ ARE
PREF. WATER MAY BE USED TO COOL CLSD (SUP DAT)
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS, & OPEN FLAME. CLSD CONTRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT (SUP DAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:USE ONLY WITH ADEQUATE VENTILATION.
AVOID BREATHING VAPOR AND SPRAY MIST. AVOID CONTACT WITH SKIN AND
EYES.
Other Precautions:THIS COATING MAY CONTAIN MATERIALS CLASSIFIED AS
NUISANCE PARTICULATES WHICH MAY BE PRESENT AT HAZARDOUS LEVELS ONLY
DURING SANDING OR ABRADING OF THE DRIED FILM.

Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
LIMS BY VENT, WEAR PROPERLY FITTED ORG VAP/PARTICULATE RESP APPRVD
BY NIOSH. WHEN SANDING/ABRADING DRIED FILM, WEAR DUST/MIST RESP
APPRVD BY NIOSH FOR D UST WHICH MAY BE GENERATED (SUP DAT)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS IS MAINT
BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS 1910.94/107/108.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
FIRE FIGHT PROC: CONTRS TO PVNT PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO
WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ: SURFS REQUIRES SPECIAL
PREC. DURING EMER CNDTNS OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HA
Z. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTN. RESP PROT:
FROM PROD, UNDERLYING PAINT/ABRASIVE.

Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:0.87
VOC Pounds/Gallon:423
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:56

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.

Waste Disposal Methods:WASTE MAY BE HAZ AS DEFINED UNDER RCRA 40 CFR
261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC EPA
HAZ WASTE NUMBERS. INCIN IN APPRVD FACILITY. DO NOT INCIN CLSD
CONTRS. DISPOSE OF I/A/W FED, STATE, & LOC REGS REGARDING
POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.